TITLE

Wear and hardness of diamondlike coatings prepared by ion beam deposition

AUTHOR(S)
Koskinen, J.; Hirvonen, J-P.; Anttila, A.
PUB. DATE
November 1985
SOURCE
Applied Physics Letters;11/1/1985, Vol. 47 Issue 9, p941
SOURCE TYPE
Academic Journal
DOC. TYPE
Article
ABSTRACT
The wear rate of 10-μm-thick 12C coatings prepared by mass separated ion beam deposition has been measured to be 60 times lower than WC+Co hard metal and 10 times lower than the conventional hard coating material TiN. The hardness of the 12C coatings was measured to be at least the same as that of the natural diamonds.
ACCESSION #
9818428

 

Related Articles

  • A review of monolithic and multilayer coatings within the boron–carbon–nitrogen system by ion-beam-assisted deposition. Jiménez, Ignacio; Torres, Ricardo; Caretti, Ignacio; Gago, Raul; Albella, Jose María // Journal of Materials Research;2012, Vol. 27 Issue 5, p743 

    A review is given on the use of ion-beam-assisted deposition (IBAD) to the growth of films within the B–C–N system, both as monolithic and multilayer coatings. The films considered include elemental, binary, and ternary materials like pure carbon (diamond-like carbon), pure boron...

  • Ion bombardment of thin layers: The effect on the interface roughness and its x-ray reflectivity (invited). Puik, E. J.; van der Wiel, M. J.; Zeijlemaker, H.; Verhoeven, J. // Review of Scientific Instruments;Jan1992, Vol. 63 Issue 1, p1415 

    In this paper we report on experiments which indicate the necessity of the use of ion-beam bombardment for e-beam deposited multilayer x-ray coatings. Measurements are described in which ion bombardment (200-300 eV Ar[sup +] ) is used to ion etch metal layers after initial deposition and during...

  • Molecular-dynamics simulation of steady-state growth of ion-deposited tetrahedral amorphous... Jager, H.U.; Albe, K. // Journal of Applied Physics;7/15/2000, Vol. 88 Issue 2, p1129 

    Reports that molecular-dynamics calculations were performed to simulate ion beam deposition of diamond-like carbon films. Simulation of carbon atom impacts on diamond; Simulation procedure; Test of the potential functions and modifications.

  • Optical properties of ion-beam-deposited ion-modified diamondlike (a-C:H) carbon. Orzeszko, S.; Woollam, John A.; Ingram, David C.; McCormick, A. W. // Journal of Applied Physics;9/1/1988, Vol. 64 Issue 5, p2611 

    Examines the optical properties of ion-beam-deposited ion-modified diamondlike carbon (DLC). Applications of DLC; Overview of previous studies on the optical properties of DLC; Details of the experimental techniques used.

  • Deposition and hydrogen content of carbon films grown by CH+3 ion-beam bombardment. Plank, H.; Wang, W.; Eckstein, W.; Schwörer, R.; Steffen, H. J.; Roth, J. // Journal of Applied Physics;11/1/1995, Vol. 78 Issue 9, p5366 

    Presents information on a study which investigated carbon deposition and hydrogen codeposition as a function of ion energy, fluence and target temperature at normal incidence by bombardment of silicon and pyrolitic graphite substrates. Experimental details; Initial film growth; Deposition rates...

  • High-dose carbon implantations into silicon: fundamental studies for new technological tricks. Lindner, J.K.N. // Applied Physics A: Materials Science & Processing;2003, Vol. 77 Issue 1, p27 

    Depending on the implantation temperature, the implantation of carbon ions into silicon at high doses results in the formation of either amorphous SiC[sub x] or crystalline 3C-SiC precipitates. Various aspects of the precipitation behaviour observed, such as the impeded nucleation, the limited...

  • Violet/blue emission from hydrogenated amorphous carbon films deposited from energetic CH[sub 3][sup +] ions and ion bombardment. Liao, Meiyong; Feng, Zhihong; Chai, Chunlin; Yang, Shaoyan; Liu, Zhikai; Wang, Zhanguo // Journal of Applied Physics;2/15/2002, Vol. 91 Issue 4, p1891 

    Considering the complexity of the general plasma techniques, pure single CH[sub 3][sup +] ion beams were selected for the deposition of hydrogenated amorphous (a) carbon films with various ion energies and temperatures. Photoluminescence (PL) measurements have been performed on the films and...

  • Transparent carbon film prepared by mass-separated negative-carbon-ion-beam deposition. Ishikawa, Junzo; Takeiri, Yasuhiko; Ogawa, Kiyoshi; Takagi, Toshinori // Journal of Applied Physics;4/1/1987, Vol. 61 Issue 7, p2509 

    Presents a study which produced carbon film by use of the negative-ion-beam deposition system. Properties of the film; Description of the mass-separated negative ion-beam deposition system; Dependence of optical gap, electrical resistivity and atomic density of the carbon film on the...

  • Ion-induced modification of graphite coatings. Gupta, B.K.; Janting, J. // Applied Physics Letters;9/7/1992, Vol. 61 Issue 10, p1177 

    Presents an ion-induced modification of a graphite-powder coating on a silicon surface. Indication of an amorphization process by bombardment results; Examination of ion-induced changes in the surface morphology at the powder surface; Analysis of the mechanical properties of the combined...

Share

Read the Article

Courtesy of THE LIBRARY OF VIRGINIA

Sorry, but this item is not currently available from your library.

Try another library?
Sign out of this library

Other Topics