TITLE

Fabrication of bulk nanocomposite magnets via severe plastic deformation and warm compaction

AUTHOR(S)
Chuanbing Rong; Ying Zhang; Poudyal, Narayan; Xiangyuan Xiong; Kramer, M. J.; Liu, J. Ping
PUB. DATE
March 2010
SOURCE
Applied Physics Letters;3/8/2010, Vol. 96 Issue 10, p102513
SOURCE TYPE
Academic Journal
DOC. TYPE
Article
ABSTRACT
We demonstrate that a SmCo/FeCo based hard/soft nanocomposite material can be fabricated by distributing the soft magnetic α-Fe phase particles homogeneously in a hard magnetic SmCo phase through severe plastic deformation. The soft-phase particle size can be reduced from micrometers to smaller than 15 nm upon deformation. Up to 30% of the soft phase can be incorporated into the composites without coarsening. A warm compaction process of the plastically deformed powder particles then produces bulk nanocomposite magnets of fully dense nanocomposites with energy product up to 19.2 MGOe owing to effective interphase exchange coupling, which makes this type of nanocomposite magnets suitable for high energy-density applications at high temperatures.
ACCESSION #
48591020

 

Related Articles

  • The extrinsic hysteresis behavior of dilute binary ferrofluids. Lin, Lihua; Li, Jian; Lin, Yueqiang; Liu, Xiaodong; Chen, Longlong; Li, Junming; Li, Decai // European Physical Journal E -- Soft Matter;Oct2014, Vol. 37 Issue 10, p1 

    Abstract.: We report on the magnetization behavior of dilute binary ferrofluids based on $ \gamma$ - FeO/NiO composite nanoparticles (A particles), with diameter about 11nm, and ferrihydrite ( FeO(OH)4HO nanoparticles (B particles), with diameter about 6 nm. The results show that for the binary...

  • Thickness dependent structural and magnetic properties of ultra-thin Fe/Al structures. Brajpuriyaa, R.; Tripathi, S.; Sharma, A.; Shripathi, T.; Chaudhari, S. M. // European Physical Journal B -- Condensed Matter;May2006, Vol. 51 Issue 1, p131 

    The structural and magnetic properties of electron beam evaporated ultra-thin Fe/Al structures are studied as a function of Fe layer thickness, while keeping the Al layer thickness constant. The grazing incidence X-ray reflectivity measurements carried out on the structures having Fe layer...

  • Aqueous ferrofluids as templates for magnetic hydroxyapatite nanocomposites. Mir, Aparna; Mallik, Dhriti; Bhattacharyya, Soumya; Mahata, Dipankar; Sinha, Arvind; Nayar, Suprabha // Journal of Materials Science: Materials in Medicine;Aug2010, Vol. 21 Issue 8, p2365 

    Poly (vinyl) alcohol stabilized aqueous ferrofluids (PVA-ff) were used as nanotemplates for the crystallization of calcium hydroxyapatite (HAp). Four sets of PVA-ff-HAp nanocomposites were synthesized using 20, 40, 60 and 80 ml of PVA-ff for the same initial constituents of HAp. Various...

  • Magnetization jumps in a lead-porous glass composite: Experiment and simulation. Tien, C.; Pirozerskii, A. L.; Charnaya, E. V.; Xing, D. Y.; Ciou, Y. S.; Lee, M. K.; Kumzerov, Yu. A. // Journal of Applied Physics;Mar2011, Vol. 109 Issue 5, p053905 

    Experimental and numerical studies of magnetization in a Pb-porous glass nanocomposite superconductor are reported. ZFC and FC magnetization revealed behavior typical for type-II superconductors with the critical temperature close to that in bulk lead. Magnetic instabilities were observed on the...

  • Time temperature transformation diagram for secondary crystal products of Co-based Co-Fe-B-Si-Nb-Mn soft magnetic nanocomposite. DeGeorge, V.; Zoghlin, E.; Keylin, V.; McHenry, M. // Journal of Applied Physics;2015, Vol. 117 Issue 17, p17A329-1 

    Secondary crystallization is the subject of much investigation in magnetic amorphous and nanocomposites (MANCs) as it limits the long term and thermal stability of their operation in device applications, including power electronics, sensors, and electric motors. Secondary crystal products...

  • A two-dimensional nematic phase of magnetic nanorods. Slyusarenko, Kostyantyn; Constantin, Doru; Davidson, Patrick // Journal of Chemical Physics;3/7/2014, Vol. 140 Issue 9, p104904-1 

    We report a hybrid mesophase consisting of magnetic nanorods confined between the non-ionic surfactant bilayers of a lamellar phase. The magnetic field-induced ordering of the nanorods was measured experimentally and modeled by a two-dimensional Onsager theory including the third virial...

  • INSTABILITY OF THE FERROFLUID LAYER ON A MAGNETIZABLE SUBSTRATE IN A PERPENDICULAR MAGNETIC FIELD. Zakinyan, A. R.; Mkrtchyan, L. S. // Magnetohydrodynamics (0024-998X);Oct-Dec2012, Vol. 48 Issue 4, p615 

    The paper presents an experimental study of the instability of a magnetic fluid layer of finite thickness covering a magnetizable metal plate exposed to a perpendicular magnetic field. The critical field strength and the instability wave number have been measured.

  • ELECTROMAGNETIC PROPAGATION AND ABSORBING PROPERTY OF FERRITE-POLYMER NANOCOMPOSITE STRUCTURE. Bayrakdar, H. // Progress in Electromagnetics Research M;2012, Vol. 25, p269 

    We have synthesized ferrite-polymer nanocomposite structures and theoretically and experimentally investigated electromagnetic propagation, absorption properties of these nanocomposite materials at 8-20GHz in microwave guides. The microwave properties of the samples were investigated by...

  • Bulk α-Fe/Nd2Fe14B nanocomposite magnets produced by severe plastic deformation combined with thermal annealing. Wei Li; Defeng Guo; Xiaohong Li; Yan Chen; Gunderov, Dmitry V.; Stolyarov, Vladimir V.; Xiangyi Zhang // Journal of Applied Physics;Sep2010, Vol. 108 Issue 5, p053901 

    Bulk α-Fe/Nd2Fe14B nanocomposite magnets with a maximum energy product up to 17.5 MG Oe have been successfully produced, using Nd9Fe85B6 with a few α-Fe crystallites in an amorphous matrix as precursors, by a combination of severe plastic deformation at room temperature and thermal...

Share

Read the Article

Courtesy of VIRGINIA BEACH PUBLIC LIBRARY AND SYSTEM

Sorry, but this item is not currently available from your library.

Try another library?
Sign out of this library

Other Topics